Product ID:AEROGLAZE 9924A WASH PRIMER
MSDS Date:09/15/1994
FSC:8010
NIIN:01-371-1952
Kit Part:Y
MSDS Number: CFWSM

LORD CORP

2000 W GRANDVIEW BLVD
ERIE, PA 16514
US

Emergency Phone: 814-763-2345

Info Phone: 814-868-3611

Cage: DO802

LORD CORPORATION, CHEMICAL PRODUCTS DIVISION

ERIE, PA 16514-0038 US

Telephone: 814-868-3611

Cage: 30676

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: <30%

OSHA PEL N/K

ACGIH TLV: N/K

CHROMATE (1-), HYDROXYOCTAOXODIZINCATEDI-, POTASSIUM; (ZINC

CAS: 11103-86-9

RTECS: GA9170000

Fraction By Weight: <15%

OSHA PEL N/K

ACGIH TLV: N/K

IRON (III) OXIDE; (IRON OXIDE)

CAS: 1309-37-1

RTECS: NO7400000

Fraction By Weight: <5%

OSHA PEL 10 MG/M3 (FE)

ACGIH TLV: 5 MG/M3 FUME (FE)

ETHYL ALCOHOL

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: <20%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

METHANOL (SARA 313) (CERCLA)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <20%

OSHA PEL 200 PPM, S

ACGIH TLV: 200 PPM; 250 STEL, S

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

SEC-BUTYL ALCOHOL; (SECONDARY BUTANOL) (SARA 313)

CAS: 78-92-2

RTECS: EO1750000

Fraction By Weight: <15%

OSHA PEL 150 PPM

ACGIH TLV: 100 PPM

DIPROPYLENE GLYCOL METHYL ETHER ACETATE

CAS: 88917-22-0

Fraction By Weight: <10%

OSHA PEL 100 PPM, S

ACGIH TLV: 100 PPM, S

5.69 LBS/GAL; 682 G/L

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

CNS DMG. CHROMATES, AS CR, HAVE BEEN DETERMD BY NTP

RTECS: 9999999ZZ

IF PROD IS SPRAYED/SANDED. MAY AFFECT GI SYS. MATL

RTECS: 9999999ZZ

PERM EYE DAMAGE OR BLINDNESS. CHRONIC SKIN CNTCT

RTECS: 9999999ZZ

VOMIT IMMED AS DIRECTED BY MED PERS. NEVER

RTECS: 9999999ZZ

CONTAIN & REMOVE W/INERT ABSORB MATL &

RTECS: 9999999ZZ

REFER TO HAZARD CAUTION INFO IN OTHER SECTIONS OF

RTECS: 9999999ZZ

REQS. STORE ONLY IN WELL-VENTD AREAS. DO NOT

RTECS: 9999999ZZ

READ & UNDERSTOOD. EMPTY CNTNRS SHOULD NOT BE

RTECS: 9999999ZZ

MADE NON-POISONOUS. USE W/ADEQ VENT. BECAUSE EMPTY

RTECS: 9999999ZZ

FROM HEAT, SPKS, FLAME; DO NOT CUT/PUNCTURE/WELD

RTECS: 9999999ZZ

NIOSH APPRVD AIR-SUPPLIED RESPIRATOR. OBSERVE

RTECS: 9999999ZZ

SOLV VAPS ARE HVR/AIR &

RTECS: 9999999ZZ

(USING EXPLOSION-PROOF EQUIPMENT) SHOULD BE

RTECS: 9999999ZZ

OR BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY CAUSE IRRIT. SKIN
CONTACT: MAY BE ABSORBED THRU SKIN IN HARMFUL AMTS. MAY CAUSE
IRRIT. MAY CAUSE DERMATITIS. INHAL: POSSIBLE IRRIT OF THE
RESPIRATORY SYSTEM CAN OCCUR CAUSING VARIETY OF SYMPS SUCH AS
DRYNESS OF THROAT, TIGHTNESS OF THE CHEST & SHORTNESS OF BRTH. MAY
CAUSE CNS DEPRESS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC POTASSIUM CHROMATE: IARC MONOGRAPHS
ON THE EVAL OF CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 49,
1990:GROUP 1.
Effects of Overexposure:HLTH HAZ: CHARACT BY FOLLOWING PROGRESSIVE
STEPS: HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCON OR
COMA. MAY CAUSE HEADACHE & NAUSEA. INGEST: NOT AN EXPECTED ROUTE OF
ENTRY IN INDUSTRIAL OR C OMMERCIAL USES. CONTAINS METHANOL; MAY BE
HARMFUL/FATAL IF SWALLOWED; INGEST OF METHANOL MAY CAUSE BLINDNESS
OR (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH EYES IMMED W/LG AMT OF WATER FOR AT LEAST 15 MIN
HOLDING EYELIDS OPEN WHILE FLUSHING. GET PROMPT MED ATTN. SKIN:
FLUSH CONTAMD SKIN W/LG AMTS OF WATER WHILE REMOVING CONTAMD CLTHG.
WASH AF FECTED SKIN AREAS W/SOAP & WATER. GET MED ATTN IF SYMPS
OCCUR. INHAL: MOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
IF BRTHG IS DFCLT, GIVE OXYGEN. GET IMMED MED ATTN. INGEST: INDUCE
(ING 12)

Flash Point Method:SCC
Flash Point:67.0F,19.4C
Lower Limits:1.3%
Upper Limits:36.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE PREF. DURING
FIRE, IRRIT &/OR TOX GASES & (SUPDAT)
Unusual Fire/Explosion Hazard:FLAM LIQ & VAP. KEEP CNTNRS TIGHTLY CLSD.
ISOLATE FROM HEAT, ELEC EQUIP, SPKS, OPEN FLAME & OTHER IGNIT
SOURCES. CLSD CNTNRS MAY RUPTURE WHEN EXPOS TO (SUPDAT)

Spill Release Procedures:KEEP NON-ESSNTL PERS A SAFE DIST AWAY FROM
SPILL AREA. REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURFS & ELEC,
STATIC OR FRICTIONAL SPKS). AVOID BRTHG VAPS. USE NIOSH APPRVD
SELF-CONTAINED BREATHING EQU IPMENT. NOTIFY APPROP AUTHS IF
NECESSARY. (ING 13)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE OR USE NEAR HEAT, SPKS OR
OPEN FLAME. REFER TO OSHA 29 CFR PART 1910.106 "FLAMMABLE &
COMBUSTIBLE LIQUIDS" FOR SPECIFIC STORAGE (ING 15)
Other Precautions:KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO PVNT LEAKAGE.
GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. AVOID SKIN & EYE
CONTACT. WASH THOROUGHLY AFTER HNDLG. AVOID BRTHG VAP OR SPRAY
MISTS. DO NOT HANDLE UN TIL ALL SFTY PRECS HAVE BEEN (ING 16)

Respiratory Protection:USE NIOSH APPRVD CHEM/MECH FILTER RESP DESIGNED
TO REMOVE COMBINATION OF PARTICULATES & ORG VAP IF OCCUP LIMS ARE
EXCEEDED. FOR EMER SITUATIONS, CONFINED SPACE USE OR OTHER CNDTNS
WHERE EXPOS LIMS MAY BE GREATLY EXCEEDED, USE A (ING 19)
Ventilation:SUFFICIENT VENT IN PATTERN & VOL SHOULD BE PROVIDED IN
ORDER TO MAINTAIN AIR CONTAMINANT LEVELS BELOW RECOMD (ING 20)
Protective Gloves:NEOPRENE, NITRILE OR RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
DISPOSABLE OR IMPERVIOUS CLTHG. REMOVE & WASH CONTAMD CLTHG BEFORE
REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMKNG OR USING TOILET
FACILITY. DO NOT SMOKE IN ANY CHEM HNDLG OR STORAGE AREA. FOOD (ING
22)
Supplemental Safety and Health
FIRE FIGHT PROC: PARTICULATE MAY BE GENERATED BY THERMAL
DECOMP/COMBUST. EXPLO HAZ: EXTREME HEAT. USE WATER SPRAY TO KEEP
FIRE EXPOS CNTNRS COOL. EFTS OF OVEREXP: PERMANENT EYE DAMAGE.
CANNOT BE MADE NON-POISONOUS. CHRONIC: MAY CAUSE LIVEROR KIDNEY
DAMAGE. RPTD/PRLNGD SOLVENT OVEREXP MAY RESULT IN PERMANENT (ING 9)

Boiling Pt:B.P. Text:>148F,>64C
Vapor Density:HVR/AIR
Spec Gravity:1.04
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:RED LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:77.4

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES AND STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES. SOURCES OF IGNITION.
Hazardous Decomposition Products:CHROMIUM FUME. CARBON MONOXIDE, CARBON
DIOXIDE.

Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
FEDERAL (40 CFR PART 261), STATE AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. IF WASTE IS DETERMINED TO BE HAZARDOUS, USE LICENSED
HAZARDOUS WASTE TRANSPORTE R AND DISPOSAL FACILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.